granite slurry as partial replacement of fine aggregate

INVESTIGATION ON GEOPOLYMER CONCRETE USING …

INVESTIGATION ON GEOPOLYMER CONCRETE USING GRANITE SLURRY POWDER AS PARTIAL REPLACMENT OF FINE AGGREGATE P. 2Pavani1, A.Roopa, Dr. J. Guru Jawahar 3, C. Sreenivasulu4 1P.G Student, Department of Civil Engineering, Shree Institute of …

Effect of Partial Replacement of Cement by Ground ...

product that is then dried and ground into the fine powder. And Marble slurry is a waste product from marble industries constitutes one of the environmental problems all over world. In this study partial replacement of OPC (43-grade) by GGBS up to 20% by total weight of OPC and Fine aggregates up to 40% by Marble slurry.

Strength and Durability Properties of Granite Powder Concrete

made with granite powder as fine aggregate. The percentage of granite powder added by weight a range viz. 0, 25, 50, 75 and as a replacement of sand used in concrete and cement was replaced with 7.5%Silica fume, 10% fly ash, 10% slag and 1% super plastiziser. The effects of curing temperature at 32 Sand 0.40 water -to-binder (w/b) ratio for 1,

Granite cutting dust - SlideShare

Mar 26, 2017· Use of granite dust in partial replacement for fine aggregate Slideshare uses cookies to improve functionality and performance, and to provide you with relevant advertising. If you continue browsing the site, you agree to the use of cookies on this website.

PARTIAL REPLACEMENT OF FINE AGGREGATE BY MARBLE …

PARTIAL REPLACEMENT OF FINE AGGREGATE BY MARBLE SLURRY CEMENT WORKS Er. R P Singh 1, Er. Arvind Singh Gaur 2 ... and 25% replacement of marble slurry gives an excellent ... ³Effect of marble and granite sludge in clay materials ´. [3] ASTM D 3910 (1996), Yearly ASTM Book of ...

Strength Properties of Concrete with Partial Replacement ...

produced with red granite dust as a partial fine aggregate replacement.‟ [3] The experimental test results showed that the use of granite dust at 20 to 50% level reduces significantly the concrete compressive strength and had little negative effects on concrete tensile strength.

Investigation on Strength Properties of Concrete with ...

fine aggregate (sand) and cement were partially replaced with Granite powder and marble powder. The replacement is done by 5%, 10%, 15%, 20%, 25% of cement by marble powder and 5%, 10%, 15%, 20%, 25% of fine aggregate by granite powder to evaluate the effect of presence of these replacement materials on the strength of specimens.

Flexural Behavior of Concrete by Partial Replacement of ...

as a partial replacement for cement and granite powder for fine aggregate. In trial mixes fine aggregate is replaced 25% of its weight by Granite powder. And cement is replaced 20% of its weight by Glass powder in all mixes. The investigation is also aimed at finding out the optimum grade of concrete for superior strength

AN EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT …

AN EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF GRANITE POWDER IN FINE AGGREGATE Name: DODDA NAGARAJU (15641D2022) M.tech (structural engineering),Vaagdevi college of engineering,bollikunta,Warangal Urban Guide: Dr.S.Sunil Pratap Reddy, Head of the Department, Civil engineering,

Project on Partial Replacement of Cement with Marble Powder

In this project our main objective is to study the influence of partial replacement of cement with marble powder, and to compare it with the compressive and tensile strength of ordinary M20 concrete. We are also trying to find the percentage of marble powder replaced in concrete that makes the strength of the concrete maximum.

(PDF) Granite waste as replacement | Surya Chowdary ...

Concrete is prepared with granite fines as a replacement of fine aggregate in 5 different proportions namely 5%, 15%, 25%, 35% and 50% and various tests such as compressive strength, Split tensile strength and Flexural strength are investigated and these values are compared with the conventional concrete without granite fines.

River Sand Substitutes -An Overview - The Masterbuilder

River Sand Substitutes. Sand Researchers world over are in continuous search for the alternatives to sand. Fine aggregate is one of the important constituents of concrete and mortar in construction industry. River sand is becoming a scarce material. Sand mining …

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF …

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF WASTE CEREMIC TILES USED AS AN ALTERNATIVE COARSE AGGREGATE IN CONCRETE S.Khaviya1 1Department of civil engineering, University College of engineering, Dindigu Abstract-The global consumption of natural aggregates is high, due to the day-by-day innovations and development in construction field.

Research Paper PARTIAL REPLACEMENT OF CEMENT WITH …

Research Paper PARTIAL REPLACEMENT OF CEMENT WITH MARBLE DUST POWDER Prof. P.A. Shirule a*, Ataur Rahman b, ... and stone slurry. Whereas solid waste results from the rejects at the mine sites or at the processing units, stone slurry is a ... The concrete mix proportion (cement: fine aggregate: coarse aggregate) is 1: 1.5: 3 by volume and a ...

Recycled aggregate concrete produced with red granite dust ...

Highlights Use of a new recycled material (red granite dust) as a partial cement replacement in concrete mixes. Selection of optimum recycled material content and the evaluation of fresh and hardened properties. RGD addition beyond 30% caused a strength decrease: mechanical properties remained acceptable up to 50% RGD-for-cement replacement.

Use of Crushed Granite Fine as Replacement to River Sand ...

Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production ... than the cost of N 18,399 per cubic metre of concrete required to produce the same grade of concrete using crushed granite as coarse aggregate and river sand as fine aggregate. Based on the above economic analysis 20% crushed granite fine is recommended for use ...

[PDF] Partial Replacement of Sand with Quarry Dust in ...

Granite fines or rock dust is a by-product obtained during crushing of granite rocks and is also called quarry dust. In recent days there were also been many attempts to use Fly Ash, an industrial by product as partial replacement for cement to have higher workability, long term strength and to make the concrete more economically available.

Suitability of Crushed Cow Bone as Partial Replacement of ...

C.A. Fapohunda et al.: Suitability of Crushed Cow Bone as Partial Replacement of Fine Aggregates for Concrete Production WIJE, ISSN 0511-5728; ...

Experimental Analysis on Partial Replacement of Fine ...

Dec 31, 2018· Upadhyaya S., Nanda B., Panigrahi R. (2019) Experimental Analysis on Partial Replacement of Fine Aggregate by Granite Dust in Concrete. In: Das B., Neithalath N. (eds) Sustainable Construction and Building Materials. Lecture Notes in Civil Engineering, vol 25. Springer, Singapore. First Online 31 December 2018

Marble Powder As Fine Aggregates in Concrete | Memon ...

Marble Powder As Fine Aggregates in Concrete Marble industry contributes significantly to the socio-economic development of any country. Due to the abundance of marble reserves, Pakistan relies on marble industry, which in turn contributes to its GDP.

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF …

a partial replacement of cement for economic status. Marble waste is a solid waste material generated from the marble processing and can be used as a filler material in cement while preparing concrete. Quarry stone is also used for the replacement for fine aggregate. Marble stone industry generates both solid waste and stone slurry.

An Experimental study on partial replacement for coarse ...

An Experimental study on partial replacement for coarse aggregate by Granite Waste. R.Siva Kumar,H.Mohammed yousuff,M.Haripriya Third Year Department Of Civil Engineering SNS College of Engineering Abstract: In developing countries where concrete is widely used, the high and steadily increasing cost of

A Review of Partial Replacement of Fine Aggregate & …

the crushed granite with coconut shell aggregate can be economically used in reinforced concrete. 3. CONCLUSIONS [2]From the above mentioned work of assorted researchers, it's clear that waste glass powder & coconut shell is used as a partial replacement of fine aggregate & coarse aggregate in

PARTIAL REPLACEMENT OF COARSE AGGREGATE WITH …

PARTIAL REPLACEMENT OF COARSE AGGREGATE WITH PORCELAIN GRANITE TILE WASTE (PGTW) IN REINFORCED CONCRETE BEAM TAN WEN CHONG Thesis submitted in fulfilment of the requirements for the award of the degree of B. Eng (Hons.) Civil Engineering Faculty of Civil Engineering and Earth Resources UNIVERSITI MALAYSIA PAHANG JUNE 2016

Partial Replacement of Coarse aggregate by Crushed Tiles ...

place of coarse aggregate and granite powder in place of fine aggregate by the percentage of 10% and 20% and 30%. The fine and coarse aggregates were replaced individually by these crushed tiles and granite powder and also in combinations that is replacement of coarse and fine aggregates …

[PDF] EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF …

Due to the increasing demand for cement, marble powder is used as a partial replacement of cement for economic status. Marble waste is a solid waste material generated from the marble processing and can be used as a filler material in cement while preparing concrete. Quarry stone is also used for the replacement for fine aggregate.

EXPERMENAL STUDIES ON M20 GRADE CONCRETE BY …

Concrete is prepared with granite fines as a replacement of fine aggregate in 6 different proportions namely 0%, 10%, 20%, 30%, 40% and 50%. The test results indicate that granite powder as replacement fine aggregate has beneficial effect on the mechanical durability properties such as compressive strength, split tensile strength and

(PDF) Partial replacement of sand by granite powder in ...

Strength And Durability Properties Of Concrete Containing Quarry Rock Dust As Fine Aggregate Narmatha.M. " Partial replacement of sand by granite powder in concrete" International Journal of ...

Copyright ©1987-2019 Company Super broken All rights reserved. sitemap